Daily Updates

March 15, 2013

Boeing aims to wrap up 787 testing in 2 weeks

Boeing unveiled its fix for its troublesome 787 battery on Friday and is aiming to wrap up testing within two weeks.

The company hopes to get quick approval from the Federal Aviation Administration, and bring an end to the grounding of the plane that began on Jan. 16. Company executives said the plane could be flying again within weeks, although aviation authorities in the U.S., Japan, and elsewhere will ultimately decide the timing.

Boeing still doesn’t know the root cause of the fire on a parked 787 Dreamliner in Boston on Jan. 7, or of the smoldering battery that forced an emergency landing on another 787 nine days later. Boeing executives said they may never know.

Instead, they’re building a battery they hope cannot burn.

The battery’s eight cells will each be wrapped in an orange tape that won’t conduct electricity. A glass laminate sheet protects the cells from the aluminum case. The wires on top are getting extra heat-resisting insulation. And the whole works now goes inside a new sealed steel tub that looks like a kitchen trash can tipped on its side. If a cell overheats, a titanium hose will carry the gases to the outside of the plane through a new inch-and-a-half hole in the fuselage.

The changes make it “very unlikely” that another battery event will happen, said Ron Hinderberger, Boeing’s vice president for 787-8 engineering.

Boeing hopes the new steel box won’t just contain a battery fire, but will prevent one from starting at all by choking off the flow of oxygen and venting the battery gases and air inside the box outside of the plane.

The new design was tested before Boeing proposed it to the FAA. It will be retested so it can be certified for use on the plane, Hinderberger said. That should be done within a week or two. After that, approval will be up to the FAA.

He said it would be inappropriate to speculate on how long that would take.

Boeing shares rose $1.81, or 2.1 percent, to close at $86.43. They’ve been rising in recent weeks as investors have been anticipating a fix for the battery problems.

Hinderberger’s assessment was more cautious than statements from other company officials, who suggested Thursday that the 787 could be flying within weeks.

Each 787 has two of the lithium-ion batteries. The fix will add 150 pounds to the weight of each plane, Hinderberger said. Weight is a key issue for the fuel efficiency of any plane, and Boeing has struggled to keep the 787 at the weight that it promised to customers.

Boeing rolled out the changes first in Japan on Friday morning, and then later in a conference call with Hinderberger. All Nippon Airways has 17 Dreamliners — more than any other airline — among the world’s fleet of 50. The emergency landing in Japan was an ANA 787, while the battery with the fire in Boston was a Japan Airlines plane. About one-third of each Dreamliner — including the batteries — are made in Japan.

Boeing officials said it’s not uncommon for airplane fixes to be applied when the root cause isn’t known. The fixes they plan for the 787 should prevent battery fires and runaway heat buildups regardless of the root cause, they said.

Boeing executives downplayed the parts of the incident that have most worried travelers. They said the only fire was on a connector on the outside of the battery box in the Japan Airlines plane, not in the battery itself. The white gas billowing out the side of the plane wasn’t smoke, but electrolyte in gas form, they said.

“We have not ruled out a fire in the battery,” NTSB spokesman Peter Knudson said after Boeing’s comments. The NTSB is leading its own investigating of the Boston fire, and is participating in the investigation in Japan.

“We saw a lot of charring inside the battery. The evidence is consistent with very high temperatures,” he said.

Boeing is also replacing the circuitry on the U.S.-made battery charger. The changes will cap the battery’s maximum charge, and will also stop draining power sooner, to prevent a so-called deep-discharge. The changes are designed to reduce the amount of energy in the battery, which should reduce its potential to generate heat, Boeing officials said.

 

1
Text Only
Daily Updates
  • NASA’s space station Robonaut finally getting legs

    Robonaut, the first out-of-this-world humanoid, is finally getting its space legs.

    April 19, 2014

  • Documents detail another delayed GM recall

    Government documents show that General Motors waited years to recall nearly 335,000 Saturn Ions for power steering failures despite getting thousands of consumer complaints and warranty repair claims.

    April 19, 2014

  • Captain of sunken SKorean ferry, 2 crew arrested

    The captain of the ferry that sank off South Korea, leaving more than 300 missing or dead, was arrested Saturday on suspicion of negligence and abandoning people in need. Two crew members also were taken into custody, including a rookie third mate who a prosecutor said was steering in challenging waters unfamiliar to her when the accident occurred.

    April 19, 2014

  • Asia seeks Obama’s assurance in territorial spats

    As President Barack Obama travels through Asia this coming week, he will confront a region that’s warily watching the crisis in Ukraine through the prism of its own territorial tensions with China.

    April 19, 2014

  • Delay won’t quell 2014 wrangling over Keystone XL

    Democrats sweating this year’s elections may be hoping that the Obama administration’s latest delay to the proposed Keystone XL pipeline takes a politically fraught issue off the table for the midterms.

    April 19, 2014

  • In Other News, April 19

    April 19, 2014

  • 5 features an Amazon phone might offer

    A report this week in The Wall Street Journal that Amazon is planning to release a smartphone has prompted industry analysts and technology blogs to muse about what the device might offer.

    April 19, 2014

  • Colorado deaths stoke worries about pot edibles

    A college student eats more than the recommended dose of a marijuana-laced cookie and jumps to his death from a hotel balcony. A husband with no history of violence is accused of shooting his wife in the head, possibly after eating pot-infused candy.

    April 19, 2014

  • Boston prepares for huge wave of marathon visitors

    With an expanded field of runners and the memory of last year’s bombings elevating interest in one of the world’s great races, the 2014 Boston Marathon could bring an unprecedented wave of visitors and an influx of tourism dollars to the area.

    April 19, 2014

  • Autopsy to ID dead boy; body cast off side of road

    All Massachusetts authorities could say for sure is that they found the lifeless body of a small boy, apparently cast off the side of a highway.

    April 19, 2014